ceramic wastes used as fine aggregate



Related Information:

Use of Ceramic Waste as Fine Aggregate in Bituminous Mix ,

03-06-2020 0183 32 While constructing bituminous pavement a mix of coarse aggregate, fine aggregate, mineral filler, and bitumen are used The demand for natural fine aggregate can be reduced by recycling waste tiles chips Waste tiles, chips aggregate refer to aggregate that has been previously used in the concrete structure as a floor finish...

Read More

PDF Effectiveness Of Ceramic Waste As Fine Aggregate In ,

Use of hazardous industrial wastes in concrete-making will lead to greener environment In ceramic industry about 30 production goes as waste, which is not recycled at present...

Read More

Use of ceramic wastes as aggregates in concrete production ,

The use of ceramic waste, originated from construction sites and industries, as fine and coarse aggregate in concrete presents an effective and sustainable endeavor to environmental problems through the reduction in the degradation of natural resources caused by extraction of natural aggregates and decrease in dumping volume as well...

Read More

THE STUDY OF USED OF CERAMIC INDUSTRIAL WASTE AS ,

Ceramic Industrial Waste CIW is needed as replacement material of fine aggregate on concrete The percentage of sludge that will use in this experiment is 10 , 20 , and 30...

Read More

Use of Ceramic Waste as Fine Aggregate in Bituminous Mix ,

34 Md Murad Hasan et al Use of Ceramic Waste as Fine Aggregate in Bituminous Mix in Flexible Pavement Design fillers 2 Using Ceramic waste aggregate 5, 10, 15, 20 replacement of natural aggregate in bituminous macadam pavement Marshal stability, flow value and were determined by the replacement of ceramic aggregates and compare with...

Read More

Use of fine recycled aggregates from ceramic waste in ,

01-03-2013 0183 32 Therefore, the use of fine recycled aggregates from ceramic waste in masonry mortar manufacturing could be a viable alternative that would help increase the recycling rate of CDW and support sustainable development in the building sector Standards used in the experimental work UNE 83115 Friability coefficient in Spanish AEN 1989 UNE 83831...

Read More

PDF The Potential Of Recycled Ceramic Waste As Coarse ,

RESULTS AND DISCUSSION w/c Type of Ceramic Slump Compressive Ratio Waste Aggregate Test Strength Properties of ceramic waste coarse aggregate mm MPa Flower pot 45 1036 From observation, it was obvious that the particle shape Tiles 35 1012 analysis of ceramic waste coarse aggregate has different 07 Clay Brick 35 particles shape with the crushed stone normal concrete...

Read More

ceramic waste as coarse aggregates and quarry dust as fine ,

ceramic waste as coarse aggregates and quarry dust as fine aggregat ceramic waste as coarse aggregates and quarry dust as fine , Use of Cement Kiln Dust, Blast Furnace Slag and - MDPI 25 Jul 2013 coarser natural aggregate were substituted with the artificial on...

Read More

Ceramic Waste Fine Aggregate Higashiyama ,

Download scientific diagram Ceramic Waste Fine Aggregate Higashiyama, Sappakittipakorn, Mizukoshi, Takahashi, 2014 from publication Sustainability for Blast Furnace Slag Use of Some ,...

Read More

ceramic waste as coarse aggregate and quarry dust as fine ,

In this process waste fine aggregates dust waste , Use of Waste Ceramic Tile Aggregates as an Alternative Material of Coarse Aggregates in Cement Concrete - written by Jaspreet Singh, Amanpreet Singh Virk, Gurpreet Singh Bath published on 2018/04/24 download full ,...

Read More

Ceramic Waste As Coarse Aggregate And Quarry Dust As Fine ,

Ceramic waste found suitable as a substitution for fine and coarse aggregate and partial substitution in cement production 2 Ceramic waste can be used as a filler material in flexible pavement 3 The ongoing research has interest in ceramic waste from different ceramic based industry which includes wall floor tiles, sanitary ware, bricks and...

Read More

Influence of Ceramic Waste as Fine Aggregate in Concrete ,

Fine ceramic aggregates prepared from various types of tableware bone china ceramic was used in concrete The raw fine bone china aggregates were evaluated for pozzolanic activity using the Frattini test, saturated lime test, and strength activity index test The compressive strength results showed that up to 60 of the fine bone china ceramic ,...

Read More

Effect of ceramic waste powder as partial fine aggregate ,

Here, ceramic waste powder CWP is used in different ratios of 25 , 50 , 75 , and 100 replacing the fine aggregate weight Aluminum powder is used to obtain aerated concrete AC Glass fibers are added in ratios of 1 , 15 , and 2 of cement weight to obtain a fiber-reinforced AC...

Read More

The Effect of Ceramic Wastes on Physical and Mechanical ,

18-12-2020 0183 32 This work aims to study the valorization and recycling of ceramic wastes wall tiles as a fine aggregate instead of sand in the manufacturing of flowable sand concrete FSC For this, the sand is substituted with the ceramic wastes at different dosages 0, 5, 10, 15, 20, and 25 by volume of the sand The influence of the ceramic wastes addition on the physical workability, density and ,...

Read More

Performance of Recycled Ceramic Waste as Aggregates in ,

for ceramic waste and granite aggregate are given in Table 2 below From the results, it was found that the ceramic waste aggregates fulfilled all the minimum requirements An asphalt binder of 80/100 penetration grade was used for the mixture preparation The results are in compliance with the road specification requirements...

Read More

Effect of Crushed Waste Ceramic Tiles CWCT as Partial ,

31-03-2018 0183 32 The reuse of crushed waste ceramic tiles as a substitute for fine aggregate in concrete has been investigated in this study Waste ceramic tiles obtained from building demolition sites and left-overs from new building sites were used The crushed waste ceramic tiles were substituted in place of fine aggregates in the following percentages 0 , 20 , 25 , 30 35 and 40 in the concrete mix...

Read More

Structural Behaviour of Crushed Fine Ceramic Tiles as ,

30 of coarse aggregate replacement 4 used crushed ceramic waste and pumice stone as a partial substitute for fine aggregates in the production of mortar and concrete, finding that the resultant product showed good compressive strength and abrasion resistance, together with less...

Read More

A Review Paper on Utilisation of Ceramic Waste in Concrete

results obtained is at 20 as fine aggregate and 10 as coarse aggregate JSwathi et al 2015 partially replaced fine aggregate with copper slag as 20 , 40 and 60 and coarse aggregate with waste ceramic tiles as 10 , 20 and 30 M40 grade of concrete was used Compressive strength increased by 759N/mm 2 at a combination of IJSER...

Read More

Ceramic Waste Effective Replacement Of Cement For ,

to find a use of ceramic waste produced Ceramic waste can be used in concrete to improve its strength and other durability factors Ceramic waste can be used as a partial replacement of cement or as a partial replacement of fine aggregate sand as a supplementary addition to achieve different properties of concrete...

Read More

PDF Use of Ceramic Wastes in Road Pavement Design

The benefits of using ceramic waste as fine aggregate in concrete containing fly ash were therefore verified View Show abstract Reusing Ceramic Wastes in Concrete Article May 2010...

Read More

Ceramic Wastes Usage as Alternative Aggregate in Mortar ,

waste ceramic addition into mortar and concrete investigated in detailed manner Throughout the literature review, it was observed that ceramic waste was used as fine/coarse aggregate in sand/gravel in producing mortar/concrete mix In these studies, effects of waste ceramic on the some mechanical and durability...

Read More

Durability of Concrete with Ceramic Waste as Fine ,

that ceramic waste can effectively been used in concrete as partial replacement of natural sand with improved strength and durability Index Terms - Crushed ceramic tiles, Cement PPC , coarse aggregate, durability, fine aggregate, compressive strength, workability I INTRODUCTION Fine aggregate is major constituent of concrete...

Read More

Use of Waste Ceramic Tile Aggregates as an Alternative ,

24-04-2018 0183 32 Pinchatorkittikul and arnonchaipanich experimented that use of ceramic waste as fine aggregates in concrete composition and concluded that the density of concrete casted with 100 percent ceramic waste aggregates was 231 g/cm3 which is 007 g/cm3 lower than with respect to conventional controlled 28 days concrete due to low specific gravity and density of ceramic waste aggregat...

Read More